二次精煉渣成分對渣中MgO飽和度的影響

顧超; 王敏; 蔡小鋒; 甘鵬

doi:10.13374/j.issn2095-9389.2018.s1.011

二次精煉渣成分對渣中MgO飽和度的影響

doi: 10.13374/j.issn2095-9389.2018.s1.011

北京科技大學鋼鐵冶金新技術國家重點實驗室

基金項目:

國家自然科學基金資助項目 (51574019)

詳細信息

通訊作者:
王敏, E-mail:worldmind@163.com

中圖分類號: TF769
計量
- 文章訪問數: 17
- HTML全文瀏覽量: 5
- PDF下載量: 0
- 被引次數: 0
出版歷程
- 收稿日期: 2018-02-15
- 網絡出版日期: 2023-07-18

Effect of the composition on MgO saturability in secondary metallurgical slag

State Key Laboratory of Advanced Metallurgy,University of Science and Technology Beijing

摘要

摘要: 在二次精煉過程中, 流動性適中且MgO飽和的精煉渣有助于渣鋼傳質, 并可以在一定程度上延長耐火材料的壽命.本研究使用熱力學計算軟件Fact Sage及熱態平衡實驗對酸性精煉渣Ca O-Si O₂-Al₂O₃-MgO四元系中MgO飽和度進行了研究.結果表明:當酸性精煉渣堿度為0.5¹.8時, 渣中MgO飽和度在2%³9%范圍內波動.當堿度增加時, MgO飽和度明顯降低.隨渣中Al₂O₃含量增加, 在MgO飽和相方鎂石相 (MgO) 和鎂橄欖石相 (2MgO·Si O₂) 中MgO飽和度逐漸增加, 在尖晶石相 (MgO·Al₂O₃) 中逐漸減少.渣中Si O₂含量對鈣硅酸鹽中MgO的飽和度有重要影響.此外, 當溫度升高時, MgO飽和度逐漸增加.
- MgO飽和度 /
- FactSage /
- 熱力學計算 /
- 精煉渣
Abstract: A predominantly liquid and MgO saturated slag is preferred in secondary metallurgical processes.It contributes to the mass transfer in molten steel and the extension of the refractory life.In the present study, the saturability of Mg O in quaternary Ca O-Si O₂-Al₂O₃-MgO system in secondary metallurgical slag with low basicity was investigated by commercial thermodynamic software and laboratory experiments.The result shows that in the basicity (Ca O/Si O₂) range of 0.5-1.8, the saturability of MgO fluctuates between2%and 39%and decreases with the increase of basicity.The saturability of MgO increases in the MgO saturated phase periclase (MgO) and forsterite (2MgO·Si O₂) and decreases in the MgO saturated phase spinel (MgO·Al₂O₃) with an increase in Al₂O₃content.Si O₂content has a great effect on the saturability of MgO in lime-silicate slag.Besides, the MgO saturability increases with an increase in temperature.
- MgO saturability /
- FactSage /
- thermodynamic calculations /
- refining slag

HTML全文

參考文獻(16)

[1]	Zhu S D, Zhang Y C. Comprehensive evaluation of the latest progress of Mg O-C refractories. Refract Lime, 2017, 42 (2) :40 (朱守丹, 張永財.全面評價Mg O--C耐火材料的最新進展.耐火與石灰, 2017, 42 (2) :40)
[2]	Kim Y J, Dong J M. Effect of Fe O and Al2O3on the Mg O solubility in CaO--Si O2-Fe O-Al2O3-Mg O slag system at 1823 K. Steel Res Int, 2012, 83 (9) :852
[3]	Wu Z D. Effect of slag on corrosion properties of Mg O--C refractories. Refract Lime, 2015, 40 (5) :15 (吳占德.渣對Mg O--C耐火材料腐蝕性能的影響.耐火與石灰, 2015, 40 (5) :15)
[4]	Yin X L, Chen M, Wang N, et al. Development of Al2O3-Mg O--CaO refractories for refining ladle. J Iron Steel Res, 2017, 29 (10) :781 (尹雪亮, 陳敏, 王楠, 等.精煉鋼包用Al2O3-Mg O--CaO系復相耐火材料的研發.鋼鐵研究學報, 2017, 29 (10) :781)
[5]	Shim J D, Banya S. Equilibrium of sulfur between liquid iron and FetO--SiO2-CaO-Mg O slags saturated with Mg O. Tetsu-toHagane, 1982, 68:251
[6]	Wu Z, Lan T. Analysis and research of saturated solubility of Mg O in the converter slag. Metall Collect, 2016, 223 (3) :13 (吳政, 蘭天.轉爐渣中Mg O的飽和溶解度分析與研究.冶金叢刊, 2016, 223 (3) :13)
[7]	Liu S H, Fruehan R J, Morales A, et al. Measurement of Fe O activity and solubility of Mg O in smelting slags. Metall Mater Trans B, 2001, 32 (1) :31
[8]	Jung S M. Equilibria of manganese and sulfur between liquid iron and CaO-Si O2--FetO-Mg O-MnO slags saturated with 2CaO·SiO2and Mg O. ISIJ Int, 2003, 43 (2) :216
[9]	Sungmo J, Changhee R, Min D J. Thermodynamic properties of manganese oxide in BOF slags. ISIJ Int, 2002, 42 (1) :63
[10]	Jung S M, Kim S H, Rhee C H, et al. Thermodynamic study on MnO behavior in Mg O-saturated slag containing Fe O. ISIJ Int, 2007, 33 (10) :1049
[11]	Bennett J, Kwong K S. Thermodynamic studies of Mg O saturated EAF slag. Ironmaking Steelmaking, 2013, 37 (7) :529
[12]	Brüggmann C, P9tschke J. Mg O saturation in secondary metallurgical lime-aluminate and lime-silicate slags. Steel Res Int, 2011, 82 (4) :422
[13]	Tsao T, Katayama H G. Sulphur distribution between liquid iron and CaO--Mg O-Al2O3-SiO2slags used for ladle refining. ISIJ Int, 2006, 26 (8) :717
[14]	Seo J D, Suito H. Sulfur distribution between Ca O-Si O2--Al2O3-Mg O slags and liquid iron and solubility of Mg O. Bull Inst Adv Mater Process Tohoku Univ, 1996, 52:23
[15]	Ohta H, Suito H. Deoxidation equilibria of calcium and magnesium in liquid iron. Metall Mater Trans B, 1997, 28 (6) :1131
[16]	Ohta H, Suito H. Activities of SiO2and Al2O3and activity coefficients of FetO and MnO in CaO-SiO2-Al2O3-Mg O slags. Metall Mater Trans B, 1998, 29 (1) :119