云南某膠磷礦AMICS工藝礦物學研究及其難選機理探討

吳中賢; 陶東平

doi:10.13374/j.issn2095-9389.2020.02.24.001

云南某膠磷礦AMICS工藝礦物學研究及其難選機理探討

doi: 10.13374/j.issn2095-9389.2020.02.24.001

吳中賢¹,
陶東平^2, ,

1.
遼寧科技大學礦業工程學院，鞍山 114051
2.
山東理工大學資源與環境工程學院，淄博 255049

基金項目: 遼寧省攀登學者人才資助項目；遼寧省重點資助項目（2017230002）

詳細信息

通訊作者:
E-mail：dptao@qq.com

中圖分類號: TD912
計量
- 文章訪問數: 3471
- HTML全文瀏覽量: 905
- PDF下載量: 72
- 被引次數: 0
出版歷程
- 收稿日期: 2020-02-24
- 刊出日期: 2021-04-26

Mineralogical analysis of collophane in Yunnan using AMICS and exploration of difficult flotation mechanisms

WU Zhong-xian¹,
TAO Dong-ping^{2
, ,}

1.
School of Mining Engineering, University of Science and Technology Liaoning, Anshan 114051, China
2.
School of Resources and Environmental Engineering, Shandong University of Technology, Zibo 255049, China

More Information

Corresponding author: E-mail: dptao@qq.com

摘要

摘要: 為了深入探討膠磷礦難選的具體原因，采用化學分析、X射線衍射以及礦物自動分析系統（AMICS）測試手段對云南某膠磷礦浮選給料進行了系統深入的工藝礦物學研究，探索了該礦樣難浮選分離的內在機理。結果表明：該樣品中磷主要以氟磷灰石形式存在，其脈石礦物以白云石和石英為主。氟磷灰石的嵌布粒度較細，主要分布于10～75 μm的粒度范圍，其單體解離度為59.17%。除了以單體的形式存在以外，氟磷灰石主要與白云石、石英連生，連生體的質量分數分別為26.23%和9.92%。而白云石和石英的單體解離度相對較低，分別為46.82%和39.10%。進行了粗選脫鎂、一粗兩掃脫硅的閉路流程浮選試驗，獲得了精礦P₂O₅品位為29.75%、P₂O₅回收率為81.95%，SiO₂品位為12.63%的浮選指標。結合工藝礦物學分析結果，指出該浮選樣品中膠磷礦嵌布粒度細、難以獲得較好的解離度、泥化嚴重是浮選難于獲得更好指標的主要原因。
- 礦物自動分析系統 /
- 工藝礦物學 /
- 膠磷礦 /
- 浮選 /
- 難選機理
Abstract: It is a global fact that the mineral ores degrade to the poor grade status and the various properties of ores are adversely altered such as fine dissemination and complex composition due to the continuous exploitation and utilization of phosphate rock resources. Consequently, separation of minerals has become a difficult and daunting task. The automatic mineral identification and characterization system (AMICS) is mostly used only for mineral characterization. There is no much research and literature on process mineralogy that integrates research parameters with flotation test results to quantitatively explore the mechanism of difficulties or problems faced during mineral separation. In this paper, to further explore and analyze the specific reasons for difficult problems faced while separating collophanite, a systematic in-depth mineralogical analysis based on the chemical analyses, X-ray diffraction, and AMICS has been performed on a refractory collophane flotation feed sample from Yunnan, China. The results show that the phosphorus in the sample mainly exists in the form of fluorapatite and also present in the gangue minerals, which are primarily dolomite and quartz. Fluorapatite has a fine dissemination particle size, which is in the range of 10–75 μm with a degree of mineral liberation 59.17%. Apart from existing in the form of liberated particles, fluorapatite is also present in dolomite and quartz as a composite particle and the mass fraction of composition in dolomite and quartz is found to be 26.23% and 9.92%, respectively. Further, dolomite and quartz relatively have a low degree of mineral liberation with the liberation degree of 46.82% and 39.10%, respectively. The closed-circuit flotation test was carried out with a rougher flotation to remove magnesium. Further a roughing and two stages of scavenging is performed which obtained the flotation performance of concentrate P₂O₅ grade of 29.75%, P₂O₅ recovery of 81.95%, and SiO₂ grade of 12.63%. When the results were studied together with the mineralogical analysis results, it is found that the fine dissemination particle size of collophanite, the poor degree of mineral liberation, and the serious slime generation are the main causes for not able to achieving a better performance in separation of minerals.
- automatic mineral identification and characterization system (AMICS) /
- process mineralogy /
- collophane /
- flotation /
- refractory mechanisms

HTML全文

圖 1 主要礦物粒度分布

Figure 1. Particle size distribution of main minerals

下載: 全尺寸圖片幻燈片

圖 2 各粒級下氟磷灰石與其他礦物的連生情況

Figure 2. Association of fluorapatite with other minerals under different grain sizes

下載: 全尺寸圖片幻燈片

圖 3 各粒級下白云石與其他礦物的連生情況

Figure 3. Association of dolomite with other minerals under different grain sizes

下載: 全尺寸圖片幻燈片

圖 4 白云石與氟磷灰石連生情況

Figure 4. Association of dolomite and fluorapatite

下載: 全尺寸圖片幻燈片

圖 5 各粒級下石英與其他礦物的連生情況

Figure 5. Association of quartz with other minerals under different grain sizes

下載: 全尺寸圖片幻燈片

圖 6 石英與氟磷灰石連生情況

Figure 6. Association of quartz and fluorapatite

下載: 全尺寸圖片幻燈片

圖 7 不同粒級產品的單體含量

Figure 7. Liberated particle content of products with different particle sizes

下載: 全尺寸圖片幻燈片

圖 8 開路流程試驗

Figure 8. Open circuit flotation flowsheet test

下載: 全尺寸圖片幻燈片

圖 9 開路流程各產品粒度分析

Figure 9. Particle size analysis of each product in the open circuit process

下載: 全尺寸圖片幻燈片

圖 10 閉路浮選流程試驗

Figure 10. Closed-circuit flotation flowsheet

下載: 全尺寸圖片幻燈片

圖 11 各產品中P₂O₅分布率與顆粒粒度的關系

Figure 11. Relationship between P₂O₅ distribution rate and particle size in various products

下載: 全尺寸圖片幻燈片

表 1 浮選藥劑

Table 1. Flotation reagents

Name	Application	Specifications	Manufacturer
Hydrochloric acid	pH Regulator	AR	Aladdin
Sodium hexametaphosphate	Depressant	AR	Aladdin
Sodium oleate	Dolomite collector	AR	Aladdin
KDJ	Quartz collector	AR	Made in laboratory
Notice：AR means analytical reagent.

下載: 導出CSV

表 2 原礦化學多元素分析結果

Table 2. Results of chemical multi-element analysis of raw ore %

P₂O₅	MgO	SiO₂	Al₂O₃	F	CaO	Fe₂O₃
21.23	6.41	14.08	1.58	3.00	51.01	1.747

K₂O	TiO₂	MnO	ZnO	SrO	ZrO₂	Na₂O
0.448	0.096	0.0691	0.0215	0.0753	0.0031	0.23

下載: 導出CSV

表 3 原礦樣品主要礦物的質量分數

Table 3. Mass fraction of main minerals in raw ore samples %

Fluorapatite	Dolomite	Quartz	Augite	Orthoclase	Kimzeyite
60.96	23.73	10.95	0.1	0.3	0.96

Armstrongite	Isokite	Calcite	Illite	Others
0.89	0.12	0.37	0.51	1.11

下載: 導出CSV

表 4 氟磷灰石的連體情況統計

Table 4. Statistics on composite particles of fluorapatite %

The mosaic type	Fluorapatite	Fluorapatite– dolomite	Fluorapatite– quartz	Fluorapatite– other
Mass fraction	59.57	26.23	9.92	4.27

下載: 導出CSV

表 5 白云石連體情況

Table 5. Statistics of composite particles of dolomite %

The mosaic type	Dolomite	Dolomite– fluorapatite	Dolomite– quartz	Dolomite– other
Mass fraction	46.20	43.67	6.09	4.04

下載: 導出CSV

表 6 石英連體情況

Table 6. Statistics of composite particles of quartz %

The mosaic type	Quartz	Quartz– fluorapatite	Quartz– dolomite	Quartz– other
Mass fraction	41.73	39.04	11.18	8.05

下載: 導出CSV

中文字幕在线观看

參考文獻(32)

[1]	Cui R G, Zhang Y F, Guo J, et al. Development strategy of phosphate rock in China under global allocation of resources. Eng Sci, 2019, 21(1): 128 崔榮國, 張艷飛, 郭娟, 等. 資源全球配置下的中國磷礦發展策略. 中國工程科學, 2019, 21(1):128
[2]	Zhang L, Yang H F, Feng A S, et al. Study on general situation and analysis of supply and demand of global phosphate resources. Conserv Utilization Miner Resour, 2017(5): 105 張亮, 楊卉芃, 馮安生, 等. 全球磷礦資源開發利用現狀及市場分析. 礦產保護與利用, 2017(5):105
[3]	Liu X, Li C X, Luo H H, et al. Selective reverse flotation of apatite from dolomite in collophanite ore using saponified gutter oil fatty acid as a collector. Int J Miner Process, 2017, 165: 20 doi: 10.1016/j.minpro.2017.06.004
[4]	Yang H Y, Xiao J F, Xia Y, et al. Origin of the Ediacaran Weng’an and Kaiyang phosphorite deposits in the Nanhua basin, SW China. J Asian Earth Sci, 2019, 182: 103931 doi: 10.1016/j.jseaes.2019.103931
[5]	Li W, Gao H, Luo Y J, et al. Status, trends and suggestions of phosphorus ore resources at home and abroad. China Min Mag, 2015, 24(6): 6 doi: 10.3969/j.issn.1004-4051.2015.06.003 李維, 高輝, 羅英杰, 等. 國內外磷礦資源利用現狀、趨勢分析及對策建議. 中國礦業, 2015, 24(6):6 doi: 10.3969/j.issn.1004-4051.2015.06.003
[6]	Abouzeid A Z M. Physical and thermal treatment of phosphate ores——an overview. Int J Miner Process, 2008, 85(4): 59 doi: 10.1016/j.minpro.2007.09.001
[7]	Zhao F T, Li R L, Liu L F, et al. Discussion on double-reverse flotation desilication process of carbonate collophanite in Yunnan. Ind Miner Process, 2019, 48(8): 48 趙鳳婷, 李若蘭, 劉麗芬, 等. 云南某碳酸鹽型膠磷礦雙反浮選脫硅工藝流程探討. 化工礦物與加工, 2019, 48(8):48
[8]	Zhou Z F, Chen M X, Sheng X F, et al. Double-reverse flotation test on medium and low grade collophanite from Fangmashan. Ind Miner Process, 2016, 45(5): 5 周澤富, 陳明祥, 盛先芳, 等. 放馬山中低品位膠磷礦雙反浮選試驗研究. 化工礦物與加工, 2016, 45(5):5
[9]	Zhou M A, Dai C, Liu L F, et al. Transformation of flotation column in Kunyang phosphate flotation plant. Mod Min, 2016, 32(6): 75 doi: 10.3969/j.issn.1674-6082.2016.06.028 周明安, 戴川, 劉麗芬, 等. 昆陽磷礦浮選廠浮選柱的改造. 現代礦業, 2016, 32(6):75 doi: 10.3969/j.issn.1674-6082.2016.06.028
[10]	Liu A, Han F, Li Z H, et al. Research progress of nano-bubble in micro-fine mineral flotation. Conserv Utilization Miner Resour, 2018(3): 81 劉安, 韓峰, 李志紅, 等. 納米氣泡在微細粒礦物浮選中的應用研究進展. 礦產保護與利用, 2018(3):81
[11]	Hoang D H, Kupka N, Peuker U A, et al. Flotation study of fine grained carbonaceous sedimentary apatite ore-Challenges in process mineralogy and impact of hydrodynamics. Miner Eng, 2018, 121: 196 doi: 10.1016/j.mineng.2018.03.021
[12]	Gui X H, Xing Y W, Wang B, et al. Fine coal flotation process intensification: part 1-a general overview of the state-of-the-art of the related research work conducted both within and abroad. Coal Prepar Technol, 2017(1): 93 桂夏輝, 邢耀文, 王波, 等. 煤泥浮選過程強化之一——國內外研究現狀篇. 選煤技術, 2017(1):93
[13]	Hoang D H, Hassanzadeh A, Peuker U A, et al. Impact of flotation hydrodynamics on the optimization of fine-grained carbonaceous sedimentary apatite ore beneficiation. Powder Technol, 2019, 345: 223 doi: 10.1016/j.powtec.2019.01.014
[14]	Yang W Q, Fang S X, Pang J T, et al. Determination of collophane monomer dissociation degree under different grinding fineness and its use in flotation. J Wuhan Inst Technol, 2014, 36(4): 31 doi: 10.3969/j.issn.1674-2869.2014.04.007 楊穩權, 方世祥, 龐建濤, 等. 膠磷礦不同磨礦細度單體解離度測定及其浮選應用. 武漢工程大學學報, 2014, 36(4):31 doi: 10.3969/j.issn.1674-2869.2014.04.007
[15]	Leistner T, Embrechts M, Lei?ner T, et al. A study of the reprocessing of fine and ultrafine cassiterite from gravity tailing residues by using various flotation techniques. Miner Eng, 2016, 96-97: 94 doi: 10.1016/j.mineng.2016.06.020
[16]	Leistner T, Peuker U A, Rudolph M. How gangue particle size can affect the recovery of ultrafine and fine particles during froth flotation. Miner Eng, 2017, 109: 1 doi: 10.1016/j.mineng.2017.02.005
[17]	Luttrell G H, Yoon R H. A hydrodynamic model for bubble-particle attachment. J Colloid Interface Sci, 1992, 154(1): 129 doi: 10.1016/0021-9797(92)90085-Z
[18]	Gu Y. Automated scanning electron microscope based mineral liberation analysis an introduction to JKMRC/FEI mineral liberation analyser. J Miner Mater Charact Eng, 2003, 2(1): 33
[19]	Fang F Y, Wang J M. The mineralogy characteristics of overflow product from hydrocyclone in the Yunnan Phosphorite Mine. Value Eng, 2019, 38(8): 162 方福躍, 王靜明. 云南某磷礦選礦廠旋流器溢流產品工藝礦物學研究. 價值工程, 2019, 38(8):162
[20]	Li H Q, Zhang W, Zheng H F, et al. Process mineralogy study of phosphate ore in Dayukou area. Ind Miner Process, 2019, 48(12): 43 李洪強, 張文, 鄭惠方, 等. 大峪口膠磷礦工藝礦物學研究. 化工礦物與加工, 2019, 48(12):43
[21]	Han M. Analysis of application of technological mineralogy in mineral processing. World Nonferrous Met, 2018(13): 242 doi: 10.3969/j.issn.1002-5065.2018.13.134 韓明. 工藝礦物學在礦物加工中的應用分析. 世界有色金屬, 2018(13):242 doi: 10.3969/j.issn.1002-5065.2018.13.134
[22]	Zhang Q, He F Y, Mao S, et al. Dissemination characteristics and grinding fineness of collophanite and dolomite. Ind Miner Process, 2010, 39(12): 8 doi: 10.3969/j.issn.1008-7524.2010.12.003 張覃, 何發鈺, 卯松, 等. 膠磷礦和白云石的嵌布特征及磨礦細度試驗. 化工礦物與加工, 2010, 39(12):8 doi: 10.3969/j.issn.1008-7524.2010.12.003
[23]	Lei?ner T, Hoang D H, Rudolph M, et al. A mineral liberation study of grain boundary fracture based on measurements of the surface exposure after milling. Int J Miner Process, 2016, 156: 3 doi: 10.1016/j.minpro.2016.08.014
[24]	de Medeiros A R S, Baltar C A M. Importance of collector chain length in flotation of fine particles. Miner Eng, 2018, 122: 179 doi: 10.1016/j.mineng.2018.03.008
[25]	Zhang Q, Tang X F, Liu J, et al. Process mineralogy of gravity concentrate of Anshan iron mine. Met Mine, 2019(2): 183 張琦, 唐學飛, 劉杰, 等. 鞍山式鐵礦重選精礦工藝礦物學研究. 金屬礦山, 2019(2):183
[26]	Zhao F T, Zhou Q B, Pang J T, et al. Summary of research status of desilication of collophane. Phosphate Compd Fertilizer, 2019, 34(6): 33 doi: 10.3969/j.issn.1007-6220.2019.06.011 趙鳳婷, 周瓊波, 龐建濤, 等. 磷礦脫硅研究現狀概述. 磷肥與復肥, 2019, 34(6):33 doi: 10.3969/j.issn.1007-6220.2019.06.011
[27]	Vieira A M, Peres A E C. The effect of amine type, pH, and size range in the flotation of quartz. Miner Eng, 2007, 20(10): 1008 doi: 10.1016/j.mineng.2007.03.013
[28]	Yu Y X, Ma L Q, Zhang Z L, et al. Mechanism of entrainment and slime coating on coal flotation. J China Coal Soc, 2015, 40(3): 652 于躍先, 馬力強, 張仲玲, 等. 煤泥浮選過程中的細泥夾帶與罩蓋機理. 煤炭學報, 2015, 40(3):652
[29]	Yao J, Xue J W, Li D, et al. Effects of fine-coarse particles interaction on flotation separation and interaction energy calculation. Part Sci Technol, 2018, 36(1): 11 doi: 10.1080/02726351.2016.1205687
[30]	Yin W Z, Li D, Luo X M, et al. Effect and mechanism of siderite on reverse flotation of hematite. Int J Miner Metall Mater, 2016, 23(4): 373 doi: 10.1007/s12613-016-1246-8
[31]	Song Z X, Han J K, Wang W Z, et al. Development and application status of flotation column technology. Met Mine, 2019(6): 20 宋子翔, 韓繼康, 王偉之, 等. 浮選柱技術發展與應用現狀. 金屬礦山, 2019(6):20
[32]	Fan M M, Tao D, Honaker R, et al. Nanobubble generation and its application in froth flotation (part II): fundamental study and theoretical analysis. Min Sci Technol (China), 2010, 20(2): 159 doi: 10.1016/S1674-5264(09)60179-4