-
摘要: 目前鎢冶煉的堿分解工藝，存在用水量大、廢水量大、加工成本高等問題，使鎢冶煉企業面臨著經濟與環保的雙重壓力，不能繼續滿足行業發展需求。對此，在大量白鎢焙燒分解工藝研究的基礎上，提出了酸法焙燒思路，開發出了硫酸鹽焙燒分解白鎢工藝，一步轉型生成WO3。由于白鎢礦焙燒產物的主要雜質為Na2SO4與難溶CaSO4，可采用鹽酸浸出方式進行鎢鈣分離，本文采用等溫平衡法，考察對比了WO3、CaSO4與WO3–CaSO4在HCl–Na2SO4溶液中的溶解行為，結果表明：WO3與CaSO4在鹽酸中的溶解度相差較大，CaSO4在鹽酸中溶解度隨溫度、鹽酸濃度的升高而增大，在溫度80 ℃、鹽酸濃度3 mol·L–1的條件下，硫酸鈣在鹽酸中的溶解度達到峰值55 g·L–1，而Na2SO4可顯著降低CaSO4在鹽酸中的溶解度，縮小CaSO4與WO3在鹽酸中的溶解差，WO3溶解度則維持在0.3～3 g·L–1范圍內，結合目前成熟的低鎢回收工藝，能將該部分溶解鎢有效地回收，即控制一定的溶解條件有利于鎢鈣高效分離。Abstract: There are numerous issues in the mainstream process of alkali decomposition of tungsten ores, such as large water consumption, large amounts of wastewater, and high processing costs, which add the dual pressure of economic and environmental protection on smelting enterprises and prevent them from meeting the industry’s development needs. As a result of a series of studies on scheelite roasting and decomposition processes, our team innovatively proposed the use of acid roasting to develop the process of sulfate decomposition of scheelite so that CaWO4 in the scheelite could be transformed directly into WO3. In addition to WO3, the roasting products contained soluble Na2SO4 and insoluble CaSO4. Because CaSO4 can be dissolved in hydrochloric acid, it can be separated from WO3 via hydrochloric acid leaching to further enrich WO3, resulting in a higher-grade material for subsequent procedures. In the presence of Na2SO4, its effect on the dissolution of WO3 or CaSO4 in hydrochloric acid will directly determine the separation effect of calcium and tungsten in the roasting products. Thus, using pure substances such as WO3, CaSO4, and Na2SO4 as raw materials, the dissolution behaviors of WO3, CaSO4, and WO3–CaSO4 in HCl–Na2SO4 solution were investigated separately via isothermal equilibrium dissolution to investigate the effects of hydrochloric acid concentration, sodium sulfate concentration, dissolution time, and dissolution temperature on the solubility of WO3, CaSO4, and WO3–CasO4 in HCl–Na2SO4 solution. The analysis shows that WO3 and CaSO4 have very different solubilities in hydrochloric acid. The solubility of CaSO4 in hydrochloric acid increases with temperature and hydrochloric acid concentration when the dissolution time is 0.5–2.5 h, the hydrochloric acid concentration is 1–5 mol·L?1, the molar ratio of HCl and Na2SO4 is 1∶2–2∶1, and the dissolution temperature is 40–80 ℃. The solubility of calcium sulfate in hydrochloric acid increases with the increase in temperature and hydrochloric acid concentration. When the temperature is 80 ℃ and the concentration of hydrochloric acid is 3 mol·L?1, the solubility of calcium sulfate in hydrochloric acid reaches a peak of 55 g·L?1. Due to the same ion effect, Na2SO4 can significantly reduce the solubility of CaSO4 and narrow the solubility difference between CaSO4 and WO3 in hydrochloric acid. CaSO4 has the highest solubility in HCl–Na2SO4 solution at 17.04 g·L?1. The dissolved WO3, whose solubility is maintained at 0.3–3 g·L?1, can be effectively recovered by using the current mature low-tungsten recovery process. Therefore, when CaSO4 and WO3 coexist in hydrochloric acid, increasing the concentration of hydrochloric acid and the dissolution temperature while decreasing the concentration of Na2SO4 can increase the solubility difference between them and achieve separation.
-
Key words:
- calcium sulfate /
- tungsten trioxide /
- sodium sulfate /
- hydrochloric acid /
- solubility
-
圖 1 鹽酸濃度、溫度對CaSO4在鹽酸中溶解的影響
Figure 1. Influence of hydrochloric acid concentration and temperature on the solubility of CaSO4 in hydrochloric acid
圖 3 時間對WO3在鹽酸中溶解的影響
Figure 3. Influence of time on the solubility of WO3 in hydrochloric acid
圖 4 溫度對WO3在鹽酸中溶解度的影響
Figure 4. Influence of temperature on the solubility of WO3 in hydrochloric acid
圖 5 鹽酸濃度對WO3在鹽酸中溶解度的影響
Figure 5. Influence of hydrochloric acid concentration on the solubility of WO3 in hydrochloric acid
圖 6 n(HCl):n(Na2SO4)對WO3在鹽酸中溶解度的影響
Figure 6. Influence of n(HCl):n(Na2SO4) on the solubility of WO3 in hydrochloric acid
圖 7 WO3–CaSO4在鹽酸溶液中的溶解情況
Figure 7. Dissolution of WO3–CaSO4 in HCl–Na2SO4 acid solution
中文字幕在线观看
圖 8 WO3–CaSO4在HCl–Na2SO4溶液中的溶解情況
Figure 8. Dissolution of WO3–CaSO4 in HCl–Na2SO4 solution
-
參考文獻
[1] Zhao Z W, Li J T, Chen X Y, et al. Technology status and development of scheelite metallurgy in China. Nonferrous Met Sci Eng, 2013, 4(5): 11趙中偉, 李江濤, 陳星宇, 等. 我國白鎢礦鎢冶煉技術現狀與發展. 有色金屬科學與工程, 2013, 4(5):11 [2] Zhao Z W, Sun F L, Yang J H, et al. Status and prospect for tungsten resources, technologies and industrial development in China. Chin J Nonferrous Met, 2019, 29(9): 1902 doi: 10.19476/j.ysxb.1004.0609.2019.09.07趙中偉, 孫豐龍, 楊金洪, 等. 我國鎢資源、技術和產業發展現狀與展望. 中國有色金屬學報, 2019, 29(9):1902 doi: 10.19476/j.ysxb.1004.0609.2019.09.07 [3] Lassner E, Schubert W D. Tungsten: Properties, Chemistry, Technology of the Element, Alloys, and Chemical Compounds. New York: Kluwer Academic/Plenum Publishers, 1999 [4] Fan J L, Liu T, Cheng U. Progress and development of tungsten-based alloys in China. China Tungsten Ind, 2009, 24(5): 99范景蓮, 劉濤, 成會朝. 中國鎢基合金的進步與發展. 中國鎢業, 2009, 24(5):99 [5] Tang P Z, Wang S C, Wang J. Historical analysis and demand forecast of global tungsten consumption. Nat Resour Econ China, 2021, 34(1): 55 doi: 10.19676/j.cnki.1672-6995.000557唐萍芝, 王壽成, 王京. 全球鎢消費歷史分析及需求預測. 中國國土資源經濟, 2021, 34(1):55 doi: 10.19676/j.cnki.1672-6995.000557 [6] Ministry of Natural Resources, People’s Republic of China. China mineral resources 2020 [R/OL]. Website Online (2021-11-5) [2022-3-25]. https://www.mnr.gov.cn/sj/sjfw/kc_19263/zgkczybg/202111/t20211105_2701985.html中華人民共和國自然資源部. 中國礦產資源報告[R/OL]. 網站公開(2021-11-5)[2022-3-25]. https://www.mnr.gov.cn/sj/sjfw/kc_19263/zgkczybg/202111/t20211105_2701985.html [7] Wang M Y, Jia M X, Xiao Y W, et al. Present situation and sustainable development countermeasures of tungsten resources in China. Nonferrous Met Eng, 2014, 4(2): 76 doi: 10.3969/j.issn.2095-1744.2014.02.018王明燕, 賈木欣, 肖儀武, 等. 中國鎢礦資源現狀及可持續發展對策. 有色金屬工程, 2014, 4(2):76 doi: 10.3969/j.issn.2095-1744.2014.02.018 [8] Shen J X. The exhaustion of wolframite resource of our country and its countermeasure. Cem Carbide, 1999, 16(2): 126申建秀. 我國黑鎢資源的枯竭及其對策(我國鎢資源優勢的危機及其對策). 硬質合金, 1999, 16(2):126 [9] Zhao Z W, Yang M F, He L H, et al. Preparation of Na specific absorbent and application of sodium removal from ammonium tungstate solution. Trans Nonferrous Met Soc China, 2014, 24(3): 854 doi: 10.1016/S1003-6326(14)63135-6 [10] He L H, Liu X H, Zhao Z W, et al. Theory and technologies on the alkali decomposition of tungsten ores. China Tungsten Ind, 2012, 27(2): 22何利華, 劉旭恒, 趙中偉, 等. 鎢礦物原料堿分解的理論與工藝. 中國鎢業, 2012, 27(2):22 [11] Ministry of Ecology and Environment of the People's Republic of China. National catalogue of hazardous waste [Z/OL]. Ruler Online (2020-11-25) [2022-3-25]. https://www.mee.gov.cn/gzk/gz/202112/t20211213_963867.shtml中華人民共和國生態環境部. 國家危險廢物名錄[Z/OL]. 規章公開(2020-11-25) [2022-3-25]. https://www.mee.gov.cn/gzk/gz/202112/t20211213_963867.shtml [12] State Taxation Administration, People’s Republic of China. Environmental protection tax law of the People’s Republic of China [Z/OL]. Ruler Online (2017-12-25) [2022-3-25]. http://www.chinatax.gov.cn/n810341/n810755/c3002759/content.html國家稅務總局. 中華人民共和國環境保護稅法[Z/OL]. 規章公開 (2017-12-25) [2022-3-25]. http://www.chinatax.gov.cn/n810341/n810755/c3002759/content.html [13] Yang J H. The theoretic and technology progresses of caustic decomposition of tungsten concentrates in China. China Tungsten Ind, 2009, 24(3): 28 doi: 10.3969/j.issn.1009-0622.2009.03.008楊金洪. 我國鎢礦物原料NaOH分解的理論與工藝研究進展. 中國鎢業, 2009, 24(3):28 doi: 10.3969/j.issn.1009-0622.2009.03.008 [14] Chen S, Dai L M, Xiong Q, et al. Analysis of the theory and technology of scheelite leaching. Value Eng, 2019, 38(26): 148 doi: 10.14018/j.cnki.cn13-1085/n.2019.26.060陳升, 戴林明, 熊慶, 等. 淺析白鎢分解的理論與工藝. 價值工程, 2019, 38(26):148 doi: 10.14018/j.cnki.cn13-1085/n.2019.26.060 [15] Zhang G Q, Guan W J, Zhang Q X, et al. Continuous-running experiment for direct solvent extraction of tungsten from autoclave-soda leaching liquor of scheeite. China Tungsten Ind, 2009, 24(5): 49 doi: 10.3969/j.issn.1009-0622.2009.05.011張貴清, 關文娟, 張啟修, 等. 從鎢礦蘇打浸出液中直接萃取鎢的連續運轉試驗. 中國鎢業, 2009, 24(5):49 doi: 10.3969/j.issn.1009-0622.2009.05.011 [16] Wan L S, Xu G Z, Yan Y H, et al. The development history and technology progress in China's tungsten metallurgy. China Tungsten Ind, 2009, 24(5): 63 doi: 10.3969/j.issn.1009-0622.2009.05.015萬林生, 徐國鉆, 嚴永海, 等. 中國鎢冶煉工藝發展歷程及技術進步. 中國鎢業, 2009, 24(5):63 doi: 10.3969/j.issn.1009-0622.2009.05.015 [17] Wan L S, Zhao L F, Huang Z H, et al. A Method of Ammonium Salt Decomposition of Scheelite: China Patent, CN102154547A. 2013-1-16萬林生, 趙立夫, 黃澤輝, 等. 一種銨鹽分解白鎢礦的方法: 中國專利, CN102154547A. 2013-01-16 [18] He L H, Zhao Z W, Yang J H. A new green process for tungsten metallurgy-synergistic decomposition of scheelite by sulfuric-phosphorous mixed acid. China Tungsten Ind, 2017, 32(3): 49何利華, 趙中偉, 楊金洪. 新一代綠色鎢冶金工藝——白鎢硫磷混酸協同分解技術. 中國鎢業, 2017, 32(3):49 [19] Guo F L, Chen X Y, Zhao Z W, et al. Behavior of accompanying rare earth during process of decomposing scheelite by sulfuric-phosphoric mixed acid. Chin J Nonferrous Met, 2018, 28(2): 387 doi: 10.19476/j.ysxb.1004.0609.2018.02.21郭福亮, 陳星宇, 趙中偉, 等. 硫磷混酸分解白鎢礦過程中伴生稀土的行為. 中國有色金屬學報, 2018, 28(2):387 doi: 10.19476/j.ysxb.1004.0609.2018.02.21 [20] Yang J B, Che W F, Hou K. Application of electric heating rotary kiln in roasting and floatation of scheelite concentrate. China Tungsten Ind, 2021, 36(1): 22 doi: 10.3969/j.issn.1009-0622.2021.01.004楊劍波, 車文芳, 候凱. 電加熱回轉窯在白鎢精礦焙燒脫浮中的應用研究. 中國鎢業, 2021, 36(1):22 doi: 10.3969/j.issn.1009-0622.2021.01.004 [21] Yang Y M, Wan L S, Zhang Z Y. Decomposition of scheelite using phosphate on alkali condition. China Tungsten Ind, 2006, 21(5): 32楊幼明, 萬林生, 張子巖. 堿性條件下磷酸鹽分解白鎢試驗研究. 中國鎢業, 2006, 21(5):32 [22] Liang X. Study on Decomposition of Scheelite by Sodium Phosphate Roasting and Recycling of Excess Sodium Phosphate [Dissertation]. Ganzhou: Jiangxi University of Science and Technology, 2018梁鑫. 磷酸鈉焙燒分解白鎢及過剩磷酸鈉循環利用研究[學位論文]. 贛州: 江西理工大學, 2018 [23] Yin Z, Zhao X D. Solubilities of calcium sulfate in hydrochloric acid and aqueous sodiium chloride solution. Oilfield Chem, 1994, 11(4): 345 doi: 10.19346/j.cnki.1000-4092.1994.04.017尹忠, 趙曉東. 硫酸鈣在鹽酸和氯化鈉水溶液中的溶解度. 油田化學, 1994, 11(4):345 doi: 10.19346/j.cnki.1000-4092.1994.04.017 [24] Zheng S C, Yu Q, Xie G, et al. Preparating of calcium sulphate whisker using phosphogypsum by recrystallization. Hydrometall China, 2016, 35(6): 488 doi: 10.13355/j.cnki.sfyj.2016.06.008鄭紹聰, 余強, 謝剛, 等. 用鹽酸溶解工業磷石膏重結晶法制備硫酸鈣晶須. 濕法冶金, 2016, 35(6):488 doi: 10.13355/j.cnki.sfyj.2016.06.008 [25] Zhang X, Liang Y, Xu L W, et al. A Method for Efficient Decomposition of Calcium Sulfate by Hydrochloric Acid: China Patent, CN113957273A. 2022-01-21張欣, 梁勇, 徐略渭, 等. 一種鹽酸高效分解硫酸鈣的方法: 中國專利, CN113957273A. 2022-01-21 [26] Zhang Y M, Ma L C, Liu C L, et al. Research on isothermal equilibrium of ternary system of RbCl-CsCl-H2O at 50 ℃. Inorg Chem Ind, 2014, 46(1): 21張永明, 馬黎春, 劉成林, 等. 50 ℃時RbCl-CsCl-H2O三元體系等溫平衡研究. 無機鹽工業, 2014, 46(1):21 [27] Ming J W, Xu W F, Zeng D W. Isothermal solubility of the ternary system LiCl-LiNO3-H2O at 273.15 K and 323. 15 K. Chin J Inorg Chem, 2007, 23(5): 883明鍵偉, 徐文芳, 曾德文. 三元體系LiCl-LiNO3-H2O 273.15K和323. 15K等溫溶解度的測定. 無機化學學報, 2007, 23(5):883 [28] Wang Y R. The interruption and its elimination of iron ion in EDTA titration of calcium and magnesium ion. J Shanghai Inst Technol, 2003, 3(4): 231王也如. EDTA滴定鈣鎂離子時鐵(Ⅲ)離子的干擾及其排除. 上海應用技術學院學報(自然科學版), 2003, 3(4):231 [29] Wang R Z, Zhu G S, Yang J D. EDTA titration method for determination of calcium ion content in low chloride ion sintering additives. Technol Manage LY Steel, 2013(2): 41王瑞珍, 朱戈莎, 楊繼東. EDTA滴定法測定低氯離子燒結助劑中鈣離子含量. 漣鋼科技與管理, 2013(2):41 [30] Standardization Administration of the People's Republic of China. GB/T 6150.1—2008 Methods for Chemical Analysis of Tungsten Concentrates - Determination of Tungsten Trioxide Content - The Ammonium Tungstate Igniting Gravimetric Method. Beijing: Standards Press of China, 2008中國國家標準化管理委員會. GB/T 6150.1—2008鎢精礦化學分析方法 三氧化鎢量的測定 鎢酸銨灼燒重量法. 北京: 中國標準出版社, 2008 [31] Ye X M. Determination of tungsten in tungsten concentrate with high stannum by gravimetric method. Chem Anal Meterage, 2016, 25(1): 67 doi: 10.3969/j.issn.1008-6145.2016.01.019葉新民. 重量法測定高錫鎢精礦中的鎢. 化學分析計量, 2016, 25(1):67 doi: 10.3969/j.issn.1008-6145.2016.01.019 [32] Zhu G B, Nie S L, Wu L Y. Determinating the tungsten mass fraction in tungsten and copper alloy using gravimetric method. Ferro-alloys, 2013, 44(6): 45 doi: 10.3969/j.issn.1001-1943.2013.06.014朱國斌, 聶淑蘭, 吳麗玉. 重量法測定鎢銅合金中鎢的質量分數. 鐵合金, 2013, 44(6):45 doi: 10.3969/j.issn.1001-1943.2013.06.014 [33] Zhang X. Study on the Preparation and Certifying Value Method of Internal Control Reference Material for Tungsten Concentrate and Roasted Molybdenum Concentrate [Dissertation]. Beijing: Beijing General Research Institute for Nonferrous Metals, 2017張煦. 鎢精礦、焙燒鉬精礦內控標樣的研制和定值方法的研究[學位論文]. 北京: 北京有色金屬研究總院, 2017 [34] Liu S Z, Zhu J H, Zhou J B, et al. Saltation phenomenon of CaSO4·2H2O solubility in (NH4)2SO4-H2O system. Phosphate &Compd Fertil, 2017, 32(4): 5 doi: 10.3969/j.issn.1007-6220.2017.04.003劉仕忠, 朱家驊, 周加貝, 等. (NH4)2SO4-H2O體系中CaSO4·2H2O溶解度的突變現象. 磷肥與復肥, 2017, 32(4):5 doi: 10.3969/j.issn.1007-6220.2017.04.003 [35] Liu H Z, Cao Y H, Wang W, et al. Recovery of molybdenum and tungsten from washwater of leaching residue of powellite ore by ion exchange. Hydrometall China, 2015, 34(1): 35 doi: 10.13355/j.cnki.sfyj.2015.01.10劉紅召, 曹耀華, 王威, 等. 離子交換法從鎢鉬氧化礦浸出渣洗水中回收鉬、鎢試驗研究. 濕法冶金, 2015, 34(1):35 doi: 10.13355/j.cnki.sfyj.2015.01.10 [36] Xu X L, Xiao L S, Zhang Q X. Recovery of tungsten from mixture solution of acid digestion mother liquid and washing water of scheelite concentrate by ion exchange method. Chin J Rare Met, 2001, 25(5): 386 doi: 10.3969/j.issn.0258-7076.2001.05.016徐曉玲, 肖連生, 張啟修. 離子交換法回收白鎢精礦酸分解母液與洗水混合液中的鎢. 稀有金屬, 2001, 25(5):386 doi: 10.3969/j.issn.0258-7076.2001.05.016 -
下載:
點擊查看大圖
圖(8)
計量
- 文章訪問數: 609
- HTML全文瀏覽量: 274
- PDF下載量: 116
- 被引次數: 0
